Vietnam’s Long Son extends cracker shutdown to June

  • : LPG, Oil products, Petrochemicals
  • 24/03/25

Vietnam's sole cracker operator Long Son Petrochemical (LSP) has extended the shutdown of its cracker and associated downstream units in Ba Ria-Vung Tau to June, to address technical issues.

LSP shut its cracker and downstream units on 21 February because of equipment issues. Siam Cement (SCG), the parent company of LSP, subsequently issued a force majeure on products the following day.

SCG was initially expecting the cracker to restart in about 2-4 weeks after the shutdown in February. But the firm filed a statement to the Stock Exchange of Thailand (SET) on 22 March, stating that the technical difficulty is still under investigation and the LSP complex is expected to restart in June.

LSP's cracker is a mixed feed cracker with a nameplate capacity of 950,000 t/yr for ethylene, 400,000 t/yr for propylene and a 100,000 t/yr butadiene extraction unit. Downstream units are polymer-focused, with a 500,000 t/yr high-density polyethylene (HDPE) plant, a 500,000 t/yr linear low-density polyethylene (LLDPE) unit and a 400,000 t/yr polypropylene (PP) unit.

SCG offered spot HDPE, LLDPE and PP supplies from its new LSP complex to the market earlier this year but has ceased offers since late February, after the force majeure announcement. SCG also stated in its statement filed to the SET that its Rayong Olefins (ROC) cracker in Map Ta Phut, Thailand has resumed operations. The producer is expected to ramp up production at its 920,000 t/yr HDPE unit and 720,000 t/yr PP unit in Thailand following the restart of the ROC cracker, and will resume supply of these grades to the market.

The ROC cracker was restarted late last week and has achieved on-specification olefins products since then, according to sources close to the company. The cracker was shut for maintenance since mid-November 2023.

The ROC cracker has a nameplate capacity of 800,000 t/yr of ethylene and 400,000 t/yr propylene. SCG also owns another cracker at the same site — the Map Ta Phut Olefins cracker with capacity of 1mn t/yr of ethylene and 500,000 t/yr of propylene. Both the crackers are currently operating at near-full run rates.


Related news posts

Argus illuminates the markets by putting a lens on the areas that matter most to you. The market news and commentary we publish reveals vital insights that enable you to make stronger, well-informed decisions. Explore a selection of news stories related to this one.

24/06/20

Shipping industry urges action to stop Red Sea attacks

Shipping industry urges action to stop Red Sea attacks

Dubai, 20 June (Argus) — The International Chamber of Shipping (ICS) has called for urgent action to stop "unlawful attacks" on commercial shipping in the Red Sea by Yemen's Houthi rebels after the sinking of a second bulk carrier since November last year. "This is an unacceptable situation, and these attacks must stop now," the ICS said. "We call for states with influence in the region to safeguard our innocent seafarers and for the swift de-escalation of the situation in the Red Sea." The Iran-backed Houthis began attacking ships in the Red Sea six weeks after the Israel-Hamas war broke out last year in what they claim is an act of solidarity with Palestinians in Gaza. The British-owned, Belize-flagged Handysize bulk carrier Rubymar sank on 4 March this year, four weeks after a Houthi attack. And the United Kingdom Maritime Trade Operations (UKMTO) said on 19 June that it believes the Greek-owned and operated bulk carrier Tutor has also sunk after the Houthis struck it with an unmanned surface vessel on 12 June. Since the attacks began, three sailors have been killed and two ships seized in separate incidents, one of which has since been freed. "We have heard the condemnation and appreciate the words of support, but we urgently seek action to stop the unlawful attacks on these vital workers and this vital industry," the ICS said. "And we must not forget the crew members from the [cargo vessel] Galaxy Leader and [containership] MSC Aries who are still being held captive." The Houthis have stepped up their attacks in recent days, prompting counter measures by US and UK military forces deployed in the area. The Red Sea is one of the world's most important shipping lanes, serving as a vital trade link between Europe and Asia. The attacks have led to an increase in freight rates and shipping insurance costs. And they have disrupted trade flows through the Suez Canal at the northern end of the Red Sea as many shipowners opt to avoid the area by taking the longer route around the southern tip of Africa. The combined flow of crude and oil products transiting the Suez Canal in both directions dropped by 34pc on the month and by 65pc on the year in May, according to preliminary data from trade analytics firm Kpler. Most oil passing through the canal southbound is now of Russian origin — 92pc in May, according to Kpler data. India, China and the Middle East were the main destinations. By Bachar Halabi Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Alberto year's first named Gulf of Mexico storm


24/06/19
24/06/19

Alberto year's first named Gulf of Mexico storm

Houston, 19 June (Argus) — A storm system in Mexico's Bay of Campeche became the first named tropical storm of this year's Atlantic hurricane season, bringing heavy rains and winds to the south Texas and northeast Mexico coasts. Tropical Storm Alberto is expected to come ashore in Mexico's Tamaulipas and Veracruz states late Wednesday or early Thursday, with maximum sustained winds of 40mph, according to the US National Hurricane Center. Heavy rain may be seen as far north as Corpus Christi, Texas, but the heaviest rains are expected inland in Mexico. Rain and heavy seas associated with the Gulf of Mexico storm system were expected to disrupt ship-to-ship lightering operations off the coast of Corpus Christi, Galveston and Beaumont-Port Arthur, Texas. The storm system does not appear to have curtailed US offshore Gulf of Mexico oil and gas production. This year's Atlantic hurricane season is expected to be more active than normal , according to the US National Oceanic and Atmospheric Administration, with 4-7 major hurricanes possible. Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Nigeria tightens sulphur cap on oil product imports


24/06/19
24/06/19

Nigeria tightens sulphur cap on oil product imports

London, 19 June (Argus) — Nigeria has reduced the sulphur cap on refined oil product imports to 50ppm, according to market participants. The new cap — which took effect at the start of June, according to sources — marks a sharp reduction from a previous 200ppm limit set on 1 March . Sources suggest there was no widespread information campaign to make market participants aware of the specification change. The lower sulphur limit comes as Nigeria braces for the imminent ramp-up of 10ppm ultra-low sulphur diesel production at the country's 650,000 b/d Dangote refinery, followed by 10ppm gasoline production in mid-July. A lower sulphur content ceiling for imports will likely favour the sale of diesel, jet fuel and gasoline from the Dangote refinery to the local Nigerian market, which until March was able to import high-sulphur products upwards of 2,000ppm. Some 10ppm diesel has already been delivered to Nigeria since the start of June, as traders have struggled to source any available 50ppm diesel to import into the country under the new cap, one trader said. Despite the regulatory change, one local Nigerian marketer told Argus that a 30,000t cargo of 150ppm gasoline is discharging in the country on 19 June, raising questions around enforcement of the new cap. By George Maher-Bonnett Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

South Korea buys less UAE naphtha in May


24/06/19
24/06/19

South Korea buys less UAE naphtha in May

Singapore, 19 June (Argus) — South Korea's naphtha imports from the UAE fell to a two-year low in May, following reduced output by Abu Dhabi's state-owned Adnoc. South Korea imported 97,500 b/d from the UAE, a 23pc drop from the previous month and down by 24pc from a year earlier, according to GTT customs data. This was the lowest level since 83,800 b/d in May 2022. This was in sharp contrast to imports in this year's first quarter that averaged 205,000 b/d. South Korea imported 192,000 b/d of naphtha from the UAE in 2023. Adnoc was expected to reduce its naphtha production and exports following a change in its domestic crude slate. Adnoc had started to divert its medium sour crude grade Upper Zakum to its Ruwais refinery complex as part of the company's $3.5bn crude flexibility project, which is designed to free up more of the UAE's lighter, sweeter Murban grade for export. The switch in Ruwais' crude appetite reduces naphtha production, as the yield of naphtha from Upper Zakum crude is less than its Murban grade, said market participants. The actual loss of supplies cannot be confirmed but it is forecast to be around 900,000-1.2mn t/yr (22,000-29,000 b/d), said two petrochemical producers that are also buyers of naphtha from Adnoc. There is also a South Korean customs investigation under way to ensure cracker operators are not importing oil from sanctioned countries such as Russia. The investigation has reduced "but not stopped" imports of naphtha from commercial storage tanks in places like the UAE and Singapore, said a South Korean trader. Adnoc is the main supplier but there are other smaller UAE suppliers in Fujairah and Hamriyah. Some Korean cracker operators are avoiding commercial tank naphtha because of the customs investigations, another South Korean trader said. Qatar and Kuwait were the main beneficiaries with South Korea's shift from UAE naphtha. South Korea's imports in May from Qatar and Kuwait rose by 89pc and 45pc month-on-month respectively. Imports from Qatar were 128,500 b/d, while shipments from Kuwait totalled 105,000 b/d. South Korea had imported 50,000 b/d from Qatar and 54,000 b/d from Kuwait in this year's first quarter. By Aldric Chew Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Malaysia's Lotte Titan yet to produce on-spec aromatics


24/06/19
24/06/19

Malaysia's Lotte Titan yet to produce on-spec aromatics

Singapore, 19 June (Argus) — Malaysian petrochemical producer Lotte Titan has yet to produce on-specification aromatics after its aromatics unit in Pasir Gudang restarted on 10 June. The unit, which can produce up to 110,000 t/yr of benzene and 60,000 t/yr of toluene, continues to face technical issues after experiencing delays to its restart date earlier this month, with flaring being observed at the Pasir Gudang complex. The company now aims to produce on-specification aromatics products by the end of the week. The associated No.2 naphtha cracker, which also restarted on 10 June, is producing on-specification olefins, although production rates remain unstable. The No.2 cracker has a nameplate capacity of 430,000 t/yr of ethylene and 220,000 t/yr of propylene. By Joonlei Lee Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Business intelligence reports

Get concise, trustworthy and unbiased analysis of the latest trends and developments in oil and energy markets. These reports are specially created for decision makers who don’t have time to track markets day-by-day, minute-by-minute.

Learn more