US OCTG market faces slow recovery in 2021
The slow recovery in the US oil and gas industry continues to crimp demand for oil country tubular goods (OCTG) and other steel pipe products used to produce and transport crude oil and natural gas products.
The energy tubular industry has found itself squeezed by twin issues — oil prices and drilling activity have been depressed since the onset of Covid-19 in the US began weighing on demand, while soaring finished steel prices have pressured margins for OCTG and pipe distributors.
Shipments of OCTG products in the US fell by 49pc in 2020 to 957,000 short tons (st) compared to the 1.87mn st shipped in 2019, according to data from the American Iron and Steel Institute (AISI). Line pipe shipments dropped by 50pc in 2020 to 322,000st compared to 649,000st in 2019.
The active oil and gas drilling rig count in the US was 402 for the week ending March 12, down by 49pc from the 792 that were active a year ago, according to data from oilfield service company Baker Hughes.
While energy industry activity has slowed, some pipe companies have had additional problems securing supply as a result of being an "inconsistent buyer" in the steel market, according to George Thompson, vice president of commercial at distributor Dura-Bond Industries. High demand from the automotive and appliance industries have taken priority for steelmakers in recent months as energy demand has remained low.
"We buy back-to-back based upon where our order book is going," Thompson said. "Consequently we end up being more or less of a flywheel-type customer for the mills, and there is no room for flywheel customers right now. We are sitting at the bottom of the stack waiting for something to drip down."
Of Dura-Bond's four steel coil suppliers, he said only one is currently willing to quote or supply him with steel. Thompson's customers are "scrounging around" for what they can find, looking for a few thousand feet of pipe compared to the tens of thousands of feet needed for many energy pipe projects.
Along with supply issues, steel prices have nearly tripled in the last seven months, with the Argus US hot-rolled coil (HRC) Midwest spot assessment up to $1,286.50/st ex-works Midwest on 16 March from a low of $450/st on 11 August. HRC is a key component used in the production of some energy-related pipe products.
As flat-rolled steel prices have increased, it has been hard for the pipe industry to pass on those costs.
"Generally 70pc of the cost of that piece of pipe is steel," said Jack McCarthy, a senior vice president at MRC Global, a pipe, valve and fitting company focused on the energy and industrial industries. "But because the pipe mills have not been able to pass along all the increases, some of them are telling me now that 80-85pc of their input cost is the steel."
The sector also views the new administration of President Joe Biden as a headwind. One of Biden's first actions was halting the construction of the Keystone XL pipeline by rescinding the cross-border permit required for the long-delayed pipeline project. The pipe for that project had been long-ago manufactured, but the move served as a signal to the sector.
"I do not think Biden is good for the oil industry, period," said Dilip Bhargava, chief executive of Houston-based SDB Steel and Pipe.
There may be other options for pipe manufacturers. On 17 March, the US House of Representatives introduced the Storing CO2 and Lowering Emissions Act (SCALE Act) to support infrastructure development for CO2 capture and sequestration, which would include pipeline infrastructure.
Related news posts
Arcadium witnesses firm January-March lithium demand
Arcadium witnesses firm January-March lithium demand
Singapore, 8 May (Argus) — US-based Arcadium Lithium said demand was "quite strong" during January-March despite the bearish tone at the start of the year, while acknowledging weaker short-term lithium demand compared with previous forecasts. "Market demand was actually quite strong and certainly not reflective of some of the ‘doomsday' scenarios," said Arcadium chief executive Paul Graves with its first-quarter results, citing still growing electric vehicle (EV) sales globally and in China. Arcadium is the merged entity of Australian lithium firm Allkem and US lithium producer Livent, which completed their merger earlier this year. Global EV sales during January-March were up by around 25pc to over 3mn units, according to the IEA, mainly driven by China. China's new energy vehicle production and sales for the quarter rose by 28pc and 32pc from a year earlier to 2.114mn and 2.089mn units respectively, according to China Association of Automobile Manufacturers data. Expectations for EV sales in China are even higher in the second quarter partly because of "new economic incentives", said Graves, likely referring to China's new automobile trade-in subsidies that has boosted the prices of some battery feedstock metals. Some industry analysts opted to lower their short-term demand forecasts to account for the higher recent sales mix of plug-in hybrid electric vehicles (PHEVs), Graves said, as sales of battery EVs (BEVs) seem to be losing ground. But Graves countered this by stating that lower BEV sales, which he concedes are expected to be lower by on average 20pc globally in 2024 and 2025 compared with forecasts a year ago, will lead to lower lithium demand that will largely be made up by demand from PHEVs and non-automotive such as stationary energy storage. Arcadium predicts only around 5pc lower demand in terms of GWh in 2024 and 2025 compared with previous forecasts, with demand to remain unchanged or even slightly higher in 2026. Output boost Arcadium is still on track to raise its combined lithium carbonate and hydroxide delivered volumes by about 40pc to 50,000-54,000t lithium carbonate equivalent this year, with volume growth weighted towards the second half of the year. It sold during January-March 30,000 dry metric tonnes (dmt) of spodumene concentrate at $827/dmt on a 5.4pc grade basis and 9,300t of lithium hydroxide and carbonate at around $20,500/t. Contrary to the prevailing view that lithium hydroxide is trading at a discount compared with lithium carbonate, Graves said that is "absolutely not the case" in their portfolio but rather it is at a "significant premium to carbonate". The company has fully commissioned the first 10,000 t/yr expansion at its Fenix lithium carbonate facility in Argentina, which is producing at close to full capacity. Its Olaroz stage two expansion in Argentina, with a nameplate capacity of 25,000 t/yr technical-grade lithium carbonate, is producing at lower rates given a longer ramp-up period. Its lithium hydroxide facilities in US North Carolina's Bessemer and China's Zhejiang with a combined 20,000 t/yr of capacity are still undergoing qualification. Arcadium is planning to expand in Argentina and Canada and expects to add 95,000 t/yr of additional nameplate production capacity by the end of 2026, which will span across spodumene, lithium carbonate and lithium hydroxide. By Joseph Ho Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
EPA sets new oil and gas methane reporting rules
EPA sets new oil and gas methane reporting rules
Washington, 7 May (Argus) — Federal regulators have updated emissions reporting requirements for oil and gas facilities as they prepare to implement a methane "waste" fee for the industry. The US Environmental Protection Agency (EPA) on Monday finalized new rules it says will improve the accuracy of data from the oil and gas sector under the federal greenhouse gas emissions reporting program. Oil and gas facility owners and operators will be required to estimate emissions from additional types of equipment under the rule, and they can draw on newer technologies, like remote sensing, to help estimate emissions. "EPA is applying the latest tools, cutting edge technology, and expertise to track and measure methane emissions from the oil and gas industry," agency administrator Michael Regan said. "Together, a combination of strong standards, good monitoring and reporting, and historic investments to cut methane pollution will ensure the US leads in the global transition to a clean energy economy." Data to support new fee The revisions to the "Subpart W" reporting requirements will be used to determine the amount of methane that will be subject to a "waste emissions charge" created by the Inflation Reduction Act. Under the law, the charge will be calculated based on the annual data that about 8,000 oil and gas sources are now required to report. The charge will begin at $900/t for 2024 methane emissions above a minimum threshold using current measurement data. It will then rise to $1,200/t in 2025 and $1,500/t in subsequent years. Industry officials had raised "serious concerns" about several aspects of the original proposal , warning it could lead to inflated emissions data. "We are reviewing the final rule and will work with Congress and the administration as we continue to reduce GHG emissions while producing the energy the world needs," American Petroleum Institute vice president of corporate policy Aaron Padilla said. The industry group previously said it will ask Congress to repeal the fee, which is only likely to occur if Republicans win control of the White House. Data collected since 2010 Oil and gas facilities have reported emissions under Subpart W since 2010. To simplify reporting, operators often count the equipment they have deployed, and use industry-wide averages to estimate emissions, in addition to other direct and indirect measurements. The industry has argued the Subpart W data is not accurate enough to collect the methane charge, which is expected to cost operators more than $6bn over the next decade. Environmental groups have had their own criticisms of the data, which they say omits vast amounts of emissions such as those from "super-emitter" events and poorly maintained flares. The final rule seeks to respond to some of those concerns by relying on updated emission factors, incorporating additional empirical data on emission rates, collecting data at a more granular level and relying on remote sensing technologies to detect large emission events. EPA also revised Subpart W to include more types of sources, including produced water tanks, nitrogen removal units and crankcase venting. The final rule also sets a threshold of 100 kg/hr of methane for requiring the reporting of emissions from "other large release events." The new data rules will take effect on 1 January 2025 and will first apply to reports submitted in early 2026 for next year's emissions. EPA is allowing the use of the new methodologies for calculating 2024 emissions, but operators can still use the existing rules. By Michael Ball Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
Pemex bajo presión para mantener refinación alta
Pemex bajo presión para mantener refinación alta
Mexico City, 7 May (Argus) — La refinación de crudo de Pemex, propiedad estatal de México, en marzo alcanzó sus niveles más altos en casi ocho años antes de las elecciones presidenciales del 2 de junio, pero la empresa podría enfrentarse a desafíos para mantener niveles de refinadoaltos en los próximos meses. Las seis refinerías nacionales de Pemex procesaron más de 1 millón b/d de crudo en marzo por primera vez desde junio de 2016, impulsadas por el progreso en la rehabilitación de las refinerías y una disminución de las exportaciones de crudo para alimentar el sistema de refinación. El presidente Andrés Manuel López Obrador busca reducir las importaciones de combustible en su último año en el cargo, en línea con su promesa de campaña de volver a México más independiente en energía. Sin embargo, los niveles de proceso de crudo podrían disminuir en abril-mayo después de que se produjeran incendios en las refinerías Minatitlán y Salina Cruz a finales de abril. Además, las refinerías de Salina Cruz (330,000 b/d) y Tula (315,000 b/d), las más grandes de México, siguen batallando con una producción elevada de combustóleo con alto contenido de azufre, lo que limita las capacidades de las refinerías para operar a altas tasas simultáneamente. Pemex lleva mucho tiempo luchando con la elevada producción de combustóleo, ya que México produce principalmente crudo pesado, lo que crea una serie de desafíos operativos. El combustóleo suele ocupar valioso espacio de almacenamiento necesario para productos de mayor valor, lo que puede limitar la producción de combustibles más ligeros. Las exportaciones récord de combustóleo en marzo, impulsadas por un aumento de la demanda en la costa del Golfo de EE. UU. después de los reacondicionamientos de la refinería, permitieron a Pemex elevar las operaciones en ambas refinerías simultáneamente. Sin embargo, el problema podría volver a afectar a Pemex en los próximos meses cuando la demanda de combustóleo disminuya y la empresa se vea obligada a almacenar el producto. Pemex está construyendo unidades de coquización en ambas refinerías para resolver este problema, pero no se espera que la unidad de Tula comience a funcionar hasta al menos finales de año, mientras que la unidad de coquización de Salina Cruz comenzaría a finales de 2025. Mientras tanto, la refinería Cadereyta de 275.000 b/d podría compensar parcialmente una disminución en el procesamiento de crudo en Tula y Salina Cruz, ya que su configuración le permite producir menos combustóleo, una fuente familiarizada con las operaciones de Pemex ha dicho a Argus . Las tasas de refinación de Pemex comenzaron a caer en 2014 después de que la administración anterior decidiera depender menos de la producción nacional y centrarse en abrir el mercado de la energía, antes hermético a inversiones externas. En cambio, López Obrador invirtió al menos $3.7 mil millones en mantenimiento para las refinerías antiguas de Pemex de 2019-2023, excluyendo proyectos importantes como las coquizadoras en construcción, además de $17 mil millones para la nueva refinería Olmeca. Cambios en el flujo de crudo y combustible Los mayores niveles de refinación de Pemex han disminuido el flujo de crudo y combustible entre México y EE. UU., y el arranque de Olmeca podría alterar aún más los flujos. Pemex redujo sus importaciones de gasolina y diésel en 25pc a 419,000 b/d en marzo, comparado con 562,000 b/d el año pasado, como resultado de un mejor rendimiento de las refinerías. Las exportaciones de crudo de México cayeron un 29pc hasta un mínimo histórico de 687,000 b/d en marzo, por una menor producción y mayores niveles de refinación. El flujo de crudo y combustible entre México y EE. UU. podría disminuir aún más una vez que Olmeca comience operaciones comerciales y si Pemex mantiene un alto nivel de refinación en sus otras refinerías. La refinería Olmeca comenzará a producir diésel de ultra bajo azufre esta semana, procesando destilados enviados desde la refinería Madero, dijo Pemex el 3 de mayo. Pero la refinería no ha cumplido varios plazos prometidos, el más reciente en abril. La unidad de destilación de crudo de la refinería, la primera unidad de procesamiento, se enfrenta a "problemas importantes" que han retrasado el inicio de la refinería, aunque otras unidades de procesamiento secundario están listas para comenzar, dijo a Argus una fuente familiarizada con las operaciones de Pemex. Sin embargo, el mercado se mantiene escéptico de que se puedan mantener los niveles de refinación después de las elecciones del 2 de junio, ya que Pemex sigue enfrentándose a problemas operativos en sus refinerías. Pero la candidata del partido gobernante Claudia Sheinbaum lidera la votación con doble dígito y se espera que continúe el proyecto actual del gobierno para reforzar Pemex y aumentar los niveles de refinación de la empresa. Por Antonio Gozain Exportaciones de crudo, importaciones de combustible de Pemex ’000 b/d Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
US set to resume crude purchases for SPR
US set to resume crude purchases for SPR
Washington, 7 May (Argus) — The US is set to resume crude purchases for the US Strategic Petroleum Reserve (SPR), after calling off a planned 3mn bl refill last month following a rise in crude prices. The US Department of Energy (DOE) today said it plans to purchase up to 3.3mn bl of sour crude for delivery in October to the SPR's Big Hill storage site in Texas. The solicitation sets a maximum price of $79.99/bl for the offers, a slight increase from the $79/bl ceiling it used in the recent monthly purchases. The agency last month called off two pending solicitations that sought to buy 1.5mn bl/month for delivery to the SPR's Bayou Choctaw site in August and September, citing higher crude prices. The most recent SPR refill, nearly 2.8mn bl of sour crude for delivery in September, cost an average of $81.34/bl. DOE says it has has already purchased a total of 32.3mn bl at an average price of $76.98/bl, well below the average $95/bl it received from the sale of 180mn bl of crude from the SPR to respond to market turbulence after Russia invaded Ukraine in 2022. Energy secretary Jennifer Granholm told lawmakers last week that two out of four SPR sites were undergoing maintenance and would not be able to accept SPR deliveries until the end of the year. "We want to continue to fill it, and we will," Grahnolm said. The SPR held 367.2mn bl as of 3 May. By Haik Gugarats Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
Business intelligence reports
Get concise, trustworthy and unbiased analysis of the latest trends and developments in oil and energy markets. These reports are specially created for decision makers who don’t have time to track markets day-by-day, minute-by-minute.
Learn more