Viewpoint: European refiners cautious on cusp of 2022
European refinery output has climbed back towards pre-pandemic levels over 2021, but growth could stall in the first months of 2022 as a result of renewed lockdown measures to curb the spread of the Covid-19 Omicron variant and high natural gas prices.
Middle distillates, which account for half of European refinery output, have been trading at margins of $12-14/bl to crude in December. That is proving enough to justify refinery utilisation at the bottom end of the 2019 range of 78-85pc. In November, crude throughputs in the EU-15 and Norway returned to around the 9.41mn b/d recorded in August, according to Euroilstock. That was the highest of the pandemic era and put utilisation at 78.1pc. This compares with throughput of 9.84mn b/d in November 2019 and utilisation of 78.6pc. But with the Netherlands introducing a full lockdown, uncertainty over other countries following suit and seasonally low gasoline demand, there will be little incentive to increase runs any further until driving activity picks up again after the spring maintenance season.
Perhaps the greatest risk for refiners in the early months of 2022 is that countries could reinstate travel restrictions and massively reduce jet fuel demand again. In 2020, the surplus of jet fuel supply was so severe that some plants had to halt crude distillation because they could not sell the product and they had exhausted their capacity to store it. France has blocked entry from the UK unless travellers have compelling reasons. If the US and other European countries were to make similar moves, then a fresh build up could result.
Electricity prices and hydrogen production costs are likely to remain elevated going into next year, on the back of high natural gas prices, and this will continue to put pressure on European refiners. Hydrogen is used in hydrocracking and hydrotreating units. TotalEnergies and UK-Chinese joint venture Petroineos have both switched off hydrocrackers in recent months, possibly for this reason. Hydrogen in the autumn this year cost refiners as much as $5-6 per barrel of crude processed, compared with around 60¢ in 2019, according to the IEA.
High natural gas prices have also contributed to a rapid rise in the cost of EU emission allowances. The IEA forecast in December that the allowances could cost as much as 90¢ per barrel of crude processed in 2022, up from around 75¢ at the end of 2021 and just 20¢ in 2019-20. Refiners of sour crude grades need the most of these allowances and also need the most hydrogen, meaning their profit margins are now under particular strain.
As 2021 draws to a close, product margins to crude are strong enough to make up for these unusual costs for most refineries. But if new lockdown measures were to push those margins down with natural gas still in short supply, hydrocracker units and refiners of sour crude grades may find themselves on thin ice.
Margins will receive little support from the spring refinery maintenance, which is likely to be relatively light, just like the autumn maintenance season in 2021. Firms conducted as much maintenance as possible during 2020 and the spring of 2021, while product margins to crude were still very low. And some refiners brought forward maintenance programmes, which has left a lighter load outstanding.
More European refinery capacity will probably come under threat over the coming year, but the pace of closures could slow down now that economics have substantially improved. More than 800,000 b/d — more than 5pc of the continent's crude distillation capacity — has already exited the market or been earmarked for closure since the start of the pandemic. Some of these sites are being converted to process biofuels.
The pressure to decommission or convert units is not only a result of the pandemic devastating margins, but in fact a long-term trend as capacity expands in the Middle East and Asia-Pacific, where operating costs are lower. For example, Saudi Aramco will bring a new 400,000 b/d refinery online next year at Jizan in Saudi Arabia.
Oil majors have been steadily trimming their exposure to Europe's refining industry, in another gloomy signal for the sector's long-term future. In 2021, Shell confirmed the sale of the 70,000 b/d Fredericia refinery in Denmark to US firm Postlane Partners. It has also sold its 37.5pc stake in the 226,000 b/d Schwedt refinery in Germany to Russia's Rosneft. This leaves the company with three fully-owned facilities in Europe, of which one is scheduled for permanent closure in 2025. TotalEnergies and Shell have shed 10pc and 15pc of their European refining capacity, respectively.
Related news posts
General Petroleum expands UAE base oil storage facility
General Petroleum expands UAE base oil storage facility
Singapore, 7 May (Argus) — UAE-based lubricant producer General Petroleum plans to finish building the second phase of its UAE base oil storage terminal by the end of May, according to a source close to the firm. The construction started in March and will consist of 12 storage tanks, each with a 2,200t capacity. The producer aims to start operations at the second phase in June. Construction for a third phase is also scheduled to begin in June 2025, which will add four storage tanks of 6,000t capacity each. The first phase of the storage terminal started operations in March 2020 . That storage terminal consisted of eight storage tanks, each with a 1,550t capacity. The facility, located in the Hamriyah free zone in Sharjah, is expected to have a combined 62,800t base oil storage capacity after the phase three expansion is complete. The terminal is connected by two pipelines to the jetty. General Petroleum operates a 150,000 t/yr lubricant plant opposite the storage terminal, and exports more than a third of its production to overseas markets, the same source added. The company had highlighted North Africa, Asia-Pacific, and the Americas as key markets for growth. The blender also has a 25,000 t/yr production facility in Tanzania and a 35,000 t/yr facility in Uganda. The UAE is a major lubricant blending and trading hub in the region because of its strategic location and logistics infrastructure. The Mideast Gulf is also largely self-sufficient on base oil supply and is typically a net exporter of the lubricant feedstock, especially for Group I and Group III supplies. Regional base oil supply is set to rise in the years ahead with planned expansions. Africa is a growing market for base oils, propelled by its gross domestic product and population growth. Rising mobility needs and vehicle ownership is also expected to boost demand in the years ahead. Africa predominantly produces Group I base oils but remains structurally short on supply. Overseas supplies, including those from the Mideast Gulf, make up a sizeable portion of the region's imports. By Chng Li Li Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
Brazil unlocks relief spending to flooded state
Brazil unlocks relief spending to flooded state
Sao Paulo, 6 May (Argus) — Brazil's president Luiz Inacio Lula da Silva signed a decree to ease relief spending to Rio Grande do Sul state, which has been hit with historically heavy rainfall and floods. "We are going to do everything in our power to contribute to Rio Grande do Sul's recovery," he said today after signing the decree, adding that was only the first of "a large number of acts" for the state. The decree recognizes the state of emergency in Rio Grande do Sul and allows the federal government to grant funding and tax waivers to the state without having to comply with spending limits. In addition, it makes rules for public authorities to contract services and purchase products more flexible. The decree still needs both senate and congressional approval — which should be hasty, as both the senate and house leaders were present at the decree's signing. It is still not clear how much money it will take to rebuild the state, chief of staff Rui Costa and planning minister Simone Tebet said. But the minister of regional integration Waldez Goez estimated that it will take around R1bn ($200mn) to rebuild the state's highways. Rio Grande do Sul has been hit with heavy rainfall since 29 April. The highest volumes reached the central areas of Rio Grande do Sul, with cities receiving rainfall of 150-500mm (6-20 inches), regional rural agency Emater-RS data show. The monitoring station of Restinga Seca city, in the center of the state, recorded rainfall of about 540mm. Rainfall in Rio Grande do Sul overall surpassed 135mm in most of the state, according to the US National Oceanic and Atmospheric Administration (NOAA). State capital Porto Alegre is expected to receive more rain later this week, according to Rio Grande do Sul-based weather forecaster MetSul. MetSul warned that parts of the Porto Alegre metropolitan area could remain uninhabitable for weeks or months. The floods have left at least 83 dead and 111 missing, according to the state government. An additional 130,000 people have been displaced from their homes. By Lucas Parolin Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
Brazil lowers biofuel mix in flooded state
Brazil lowers biofuel mix in flooded state
Sao Paulo, 6 May (Argus) — Brazil's oil regulator ANP temporarily decreased the mandatory mix of ethanol and biodiesel in fuels in Rio Grande do Sul state for 30 days, starting on 3 May, amid floods in the region. The anhydrous ethanol blend on gasoline was lowered to 21pc from the current 27pc, while the mandatory biodiesel mix for 10ppm (S10) diesel is now at 2pc, down from the usual 14pc. The agency also temporarily suspended the blending mandate for diesel with 500ppm of sulfur (S500). ANP said it can revise deadlines depending on supply conditions in the state. Rainfall in Rio Grande do Sul blocked railways and highways where biofuels are transported to retail hubs, such as Esteio and Canoas. Supply of fossil fuels via pipeline from the 201,000 b/d Alberto Pasqualini refinery (Refap), in Canoas, and other retail bases has not been compromised, ANP said. Floods in Rio Grande do Sul have left at least 83 dead and 111 missing, according to the state government. More than 23,000 people have been forced from of their homes amid widespread damage. Over 330 cities are in a situation of public calamity. By Laura Guedes Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
North Germany sees May holiday gasoline surge
North Germany sees May holiday gasoline surge
Hamburg, 6 May (Argus) — Driving activity in Germany increased around the public holiday on 1 May, leading to a rise in regional demand for fuels, particularly gasoline, in the past week. Oversupply of diesel is also pressuring premiums in Europe. Daily volumes of diesel and E5 gasoline reported to Argus this week were higher than the average for the current year. Demand for gasoline in the North region notably increased, with reported volumes in the past week reaching the highest daily average in 2024. The filling station sector is almost entirely responsible for the increased demand, market participants said. Many end-users took Monday and Tuesday off as additional holidays, leading up to 1 May. This resulted in a temporary increase in travel activity. In anticipation of this, filling station operators stocked up on fuel. But compared with previous years, overall demand for diesel in Germany remains weak. Coupled with plenty supply of diesel on the international market, this has led to premiums of cif Hamburg in April reaching their lowest level since July 2023. In the face of oversupply the difference between cif Hamburg diesel and cif ARA assessment fell further as well over the past week. The volume of diesel imported to northern Germany increased by 18pc in April compared with March, reaching around 71,000 b/d, data from Vortexa show. The low premiums of the diesel cif assessments, along with the ICE Gasoil Future's contango — which has encouraged the storage of product in tanks since mid-April — have particularly boosted import demand. By Johannes Guhlke Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
Business intelligence reports
Get concise, trustworthy and unbiased analysis of the latest trends and developments in oil and energy markets. These reports are specially created for decision makers who don’t have time to track markets day-by-day, minute-by-minute.
Learn more